Schwank STSp-CANADA Manuel d'utilisateur

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH INSTALLATION / OWNER’S MANUAL SCHWANK GAS FIRED STS-p SERIES LOW INTENSITY TUBE TYP

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH 7. SYSTEMS INCORPORATING 90O ELBOWS AND 180O ELBOWS Page 6 The STS-p Series radiant tube heater

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 7 8. SUSPENSION SYSTEM End plate hangers are provided to support reflectors and tubes at bo

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH FIGURE 6 END PLATE HANGER/ELBOW INSTALLATION 9– Focus shield Reflector *** 10- Flue Vent te

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 8 Page 9 FIGURE 7 HANGER / REFLECTOR ORIENTATION HORIZONTAL TO 450 FIGURE 8 SUGGESTED M

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 10 9. BURNER AND TUBE INSTALLATION With all hangers suspended at the same height, insert fi

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 11 TABLE 4 MODEL TURBULATOR LENGTH (IF REQUIRED) STS-p 200-70/60/50 10’ STS-p 175-70/60/5

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 12 10. FOCUS SHIELD REFLECTOR INSTALLATION After burner and tubes have been installed, slide

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 13 NOTE: For angle mounted applications use the reflector stabilizer(s) See FIGURE 9 (PAGE 9

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 14 FIGURE 16 REFLECTOR EXTENSIONS (OPTIONAL - IF REQUIRED ) • Using “S” Hooks attach

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 15 11. FLUE VENTING The STSp series is approved for both direct and indirect vented applicat

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH NOTICE: Schwank Inc., reserves the right to make changes to equipment and specifications without

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH When venting horizontally, the flue vent system should slope downwards approxi-mately 1/4"

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 17 Where the vent pipe passes through areas where the ambient temperature is likely to produc

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 18 For ease of installation, this heater has been provided with a fresh air intake duct hood.

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 19 DO NOT use pressures greater than 1/2 psig. to pressure check the heater. TEST FOR LEAKS:

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 20 14. HEATER EXPANSION Due to the characteristics of tube heaters, the installer must allow

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 21 IMPORTANT: Do not install the thermostat or sensors in the direct radiant stream.

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 22 17. LIGHTING INSTRUCTIONS Refer to the lighting instructions on the inside cover of the bu

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 23 CA Series: The STS-p Burner with direct spark ignition, sequence is as follows : 1. U

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 24 STSp-CA SERIES: WIRING DIAGRAM - HONEYWELL S87J1034 WITH 120 V THERMOSTAT

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH CA SERIES: TROUBLESHOOTING GUIDE HONEYWELL S87J1034 120V THERMOSTAT APPLY 115 VOLTS CO

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH TABLE OF CONTENTS TOPIC PAGE NUMBER 1. GENERAL...

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH MAIN BURNER LIGHTS SPARK STOPS WHEN BURNER LIGHTS SYSTEM RUNS UNTIL CALL FOR HEAT ENDS CALL FOR

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH 24 VOLT OPTION AVAILABLE : STSp-CA SERIES: WIRING DIAGRAM - HONEYWELL S87J1034 Page 27 RELAY

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 28 21. SPARK IGNITION CIRCUIT The step-up transformer in the ignition control provides spark

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 29 22. START-UP SHEET START UP SHEET

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 30 TO BE COMPLETED BY THE LICENSED INSTALLER:

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH 23. OPTIONAL COMPONENTS: FOR SCHWANK STS-p SERIES TUBE HEATERS Flue Vent Terminals 4” wall

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH 90 degree Aluminized Steel Elbow Kit* (*Kit includes: elbow, coupler, and two end plate hanger

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH TruTemp Thermostat (Do Not use in wet or corrosive environments) JM-0150-XX JS-0569-

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Hanging Chain - (box of 50ft) JL-0798-XX JA-0587-XX JA-07

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 35 MODEL NO STD ORIFICE (DMS) FOR USE AT ALTITUDES ABOVE (FEET) 2000 3000 4000 5000 600

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH FOR GAS-FIRED INFRA-RED LOW INTENSITY TUBE TYPE HEATERS : STSp, STSpWP, STR, STSV SERIES Some Au

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 1 SCHWANK GAS INFRA-RED TUBE HEATER STS-P SERIES INSTALLATION INSTRUCTIONS Installation of t

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 2 4. TUBE LENGTHS AND CORRESPONDING BTU INPUT RATINGS AVAILABLE: MODEL OVERALL HEATER

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 3 HEATER MODELTS-4510-CXTS-4520-CXTS-1420-CXTS-1430-CXTS-1040-CXTS-F030-CXTS-1030-CXTS- 10

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH Page 4 5. PRE-INSTALLATION SURVEY The Schwank STS-p heating system must have gas piping of the c

SP-MSTP-AC-15A STS-p Manual RD: DEC, 2003 RL:15 KH FIGURE 1 MINIMUM CLEARANCES TO COMBUSTIBLES TABLE 3 MINIMUM CLEARANCES TO COMBUSTIBLES Page 5 M