Schwank STSp-USA Manuel d'utilisateur

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH INSTALLATION / OWNER’S MANUAL SCHWANK GAS FIRED STS-p SERIES LOW INTENSITY TUBE TY

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 7. SYSTEMS INCORPORATING 90O ELBOWS AND 180O ELBOWS The STS-p Series radiant tube heater can be

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH GENERAL INSTALLATION INSTRUCTIONS The following instructions are a guide to installation only, an

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH FIGURE 6 2. Assemble two shade end plate hangers by attaching 1 of the shade end plate

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 4. Slide the shade end plate hangers and shade plate hangers on the tubes before

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 6. After the first two tubes are assembled, the heater can be suspended and the rest

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH FIGURE 10 FIGURE 11 10. The Combustion air and vent pipe, if required can be installed

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 10” Page 12

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH TABLE 4 MODEL TURBULATOR LENGTH (IF REQUIRED) STS-p 200-70/60/50 10’ STS-p 175-70/60/50 10’ S

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 11. FLUE VENTING The STSp series is approved for both direct and indirect vented applications. I

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH When venting horizontally, the flue vent system should slope downwards approxi-mately 1/4"

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH NOTICE: Schwank Inc., reserves the right to make changes to equipment and specifications without

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Where the vent pipe passes through areas where the ambient temperature is likely to produce conden

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH For ease of installation, this heater has been provided with a fresh air intake duct hood. It can

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH DO NOT use pressures greater than 1/2 psig. to pressure check the heater. TEST FOR LEAKS: All g

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 14. HEATER EXPANSION Due to the characteristics of tube heaters, the installer must allow for 1” e

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH The voltage at the spark ignition control is 24V. Note that proper functioning of t h e hea

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 17. LIGHTING INSTRUCTIONS Refer to the lighting instructions on the inside cover of the burner hou

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH UA Series: The STS-p Burner with direct spark ignition, sequence is as follows : 1. Upon a cal

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH UA SERIES: WIRING DIAGRAM - HONEYWELL S87J1034 - 120 VOLT Page 23

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH UA SERIES: TROUBLESHOOTING GUIDE HONEYWELL S87J1034 120V THERMOSTAT PLUG INTO 115 VOLTS

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH MAIN BURNER LIGHTS SPARK STOPS WHEN BURNER LIGHTS SYSTEM RUNS UNTIL CALL FOR HEAT ENDS CALL FOR

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH TABLE OF CONTENTS TOPIC PAGE NUMBER 1. GENERAL...

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 24 VOLT FIELD MOUNTED OPTION ONLY WIRING DIAGRAM - HONEYWELL S87J1034 - 24 VOLT OPTION Page 26

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Page 27 21. SPARK IGNITION CIRCUIT The step-up transformer in the ignition control provides spark

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 22. START-UP SHEET Page 28 START UP SHEET

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Page 29 LOW INTENSITY START-UP TYPE OF GAS: NG LP DOES BUILDING HAVE A NEGATIVE CONDI

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 23. OPTIONAL COMPONENTS: FOR SCHWANK STS-p SERIES TUBE HEATERS Flue Vent Terminals 4” wall

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 90 degree Aluminized Steel Elbow Kit* (*Kit includes: elbow, coupler, and two end plate hanger

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH TruTemp Thermostat (Do Not use in wet or corrosive environments) JM-0150-XX JS-0569-

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Hanging Chain - (box of 50ft) JL-0798-XX JA-0587-XX JA-0780-XX

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH MODEL NO STD ORIFICE (DMS) FOR USE AT ALTITUDES ABOVE (FEET) 2000 3000 4000 5000 6000 7000

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH FOR GAS-FIRED INFRA-RED LOW INTENSITY TUBE TYPE HEATERS : STSp, STSpWP, STR, STSV SERIES Some Au

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Page 1 SCHWANK GAS INFRA-RED TUBE HEATER STS-P SERIES INSTALLATION INSTRUCTIONS Installation of t

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 4. TUBE LENGTHS AND CORRESPONDING BTU INPUT RATINGS AVAILABLE: MODEL OVERALL HEATER LENGTH*

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH Page 3 HEATER MODELTS-4510-AXTS-4520-AXTS-1420-AXTS-1430-AXTS-1040-AXTS-F030-AXTS-1030-AXTS- 10

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH 5. PRE-INSTALLATION SURVEY The Schwank STS-p heating system must have gas piping of the correct

SP-MSTP-AU-05A STS-p Manual RD: DEC, 2003 RL: 5 KH FIGURE 1 MINIMUM CLEARANCES TO COMBUSTIBLES TABLE 3 MINIMUM CLEARANCES TO COMBUSTIBLES MODEL SU